I've just won some Koni adjustables and Eibach springs on Ebay (£310 all together). Apart from needing a quick lick of paint and maybe a re-grease (they are obviously used!) I will be fitting them fairly shortly.
My question: How hard is it to fit the rears? The fronts look fairly simple, I've already had one shock off on my previous NG900 but I've not looked at the rears yet...
Also, how do I go about adjusting the shocks to where I want them to be? Do I need to set them to softest and then adjust from there for example?
Going to order myself some as soon as i get the cash, £290 new from www.awesome-gti.co.uk, sorry i cant be of any help but my friends just turn theirs up progressively.
If you drop into the lounge you'll see we've been out busy Saabing today.
I've fitted 2 sets so far, and koni to the rear of the vert too. Ever done dampers or springs on a cavalier? it's the same thing; the nuts can be siezed hellish tight at the strut to in the boot, give everything a good soak with release before you really start. For the rears you'll need the car up on axle stands with the roadwheels removed undo the lower damper bolt where it secures to the trailing arm on either side whilst the axle is supported by a jack on the cross member, lower the jack and the axle should swing away from the dampers and the springs are now free to swap; unbolt the damper tops and remove.
Refitting is more or less a reversal but do not torque up the bolts until the road wheels are re-fitted and back under load, it pays to have the rear up on ramps to do this. The rear dampers will need to be set 2-3 clicks harder [clockwise] to the fronts.
i ran mine quite hard , now i have the rears on 1/2 way and the fronts almost at their softest , a nice compromise , didnt work too well but i fitted the anti sway to the rear and its perfect ( doesnt bounce anymore )
good luck with that ( with eibachs matching your Konis you can really feel the rear wheel steer when on 3 wheels ) ...... so i hear .
The Abbott unit is regarded as the best ARB by some some, at £145 I should hope it is!
The MP performance unit is available from UK outlets, it's OK, when you consider how much one costs [I've got an MP unit on one car] and that you can get a second bar for next to nothing and double stack them [my other 900 has this] then they all seem not very good value.
You can sort of test shocks the hard way by holding one end in a vice and try to make them move one way then the other, they should control you almost instantly - then consistently through the travel.
The rust, at the rear arch? where the inner wing and wheel well are jojned and the damper passes through? If so , clean this area, buy a curerust type product and follow its instructions, seal the area in with paint and body sealant, only now do you fit the damper, but make sure you use some silicone sealant to bed the wheel arch side rubber bush to the recently patched up steel. If you are lucky [and thorough] the rust may not come back.
The thing I like about this set up for the NG900 / 9-3 as compared to my old 9000 is that the rear shocks are adjustable from the top. The Koni's on my old 9000 were only adjustable if you loosened the lower bolt and twisted the shock. Nice set up though. http://www.kyankton.net/saabng900/saabng900.htm
The rust, at the rear arch? where the inner wing and wheel well are jojned and the damper passes through? If so , clean this area, buy a curerust type product and follow its instructions, seal the area in with paint and body sealant, only now do you fit the damper, but make sure you use some silicone sealant to bed the wheel arch side rubber bush to the recently patched up steel. If you are lucky [and thorough] the rust may not come back.
The rust isn't on the car, its on the Konis. There are holes at the top of the rear struts (presumably to vent air...) and they are slightly corroded around the holes.
This is an older thread, you may not receive a response, and could be reviving an old thread. Please consider creating a new thread.
Related Threads
?
?
?
?
?
SaabCentral Forums
3M posts
119.2K members
Since 2001
SaabCentral forum the most comprehensive Saab resource on the internet. Join our discussions on the Saab 9-3, Saab 9-5, Saab 900, Saab 9000 and all other Saab models, choose your forum.